Benjamin Gawert wrote:
Eunometic schrieb:

The PA200 Tornado is fully FBW with a mechanical linkage backup system...

Benjamin


Then why does it need a thermal backup battery to remain airborn?

Because besides power for certain important instruments and the radio
the EPS battery also powers an electric motor that powers a hydraulic pump.

"Mechanical linkage" does not mean that the stick is connected to
pushrods and levers that move the control surfaces (which would be silly
on a fighter/bomber aircraft with up to ~55000 pounds weight).

Which means that PA200 Tornado when using 'mechanical' backup is
actually fully power opperated as opposed to power assisted (power
assisted can be designed to connect into a fully manual system with
limited movement). Given the need for power it doesn't seem to make
much sense to bother to use a mechanical system at all. An additional
layer of redundancy and an 'analog' backup would be better use of the
weight. Perhaps Panavia was worried about Electromagnetic Pulse or
Weapons. I believe F-16 uses fiber optics.

When in
so-called "mech mode" the stick is connected to several hydraulic valves
that control the hydraulic actuators. So you need hydraulics pressure,
and in cases of double engine out this hydraulic pressure comes from an
electric pump that powered by the EPS battery.

In normal operation the potentiometers connected to the stick submit
stick position data to the flight control system (CSAS and SPILS) which
calculate the necessary control surface deflection and control the
corresponding actuators.

They use potentiometers? I though LVDT were normally used.

The mechanical linkage is inactive (in
emergencies the stick gets linked to the mechanical controls through a
honeycomb block which gets squeezed by the stick movement applied by the
panicing pilot ;-)

This applies to the GR versions (bomber), I don't know if the F versions
are somewhat different.

Benjamin