If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#51
|
|||
|
|||
glider battery duration problems
Dan Marotta wrote, On 10/5/2013 8:22 AM:
This looks very interesting to me: http://www.bioennopower.com/collecti...ifepo4-battery On the surface it appears that I may be able to wire two of them in parallel (or series-parallel if individual cells) and enclose them in the battery case that fits in the tail of my LAK. I'll measure it today and see if there's a chance. Be certain to read the user manual for this battery, which specifically states series or parallel operation is not recommended! The manual also states "Only use 14.6V, LiFePO4 compatible chargers to charge the battery. The charging current should be between 2A to 5A. If you need a charger, please contact us" Don't rely on claims for other Li batteries, like "any lead acid charger can be used", but only go by the requirements of the manufacturer of the battery you have. Lithium based batteries must be taken more seriously than SLA batteries, which are nearly identical from one manufacturer to another. Lithium batteries, even LiFePO4, can vary substantially in their characteristics, particularly with the type of BMS (battery management system) installed in it, and may not even have one. Even the proper storage varies considerably between Li and lead batteries. -- Eric Greenwell - Washington State, USA (change ".netto" to ".us" to email me) |
#52
|
|||
|
|||
glider battery duration problems
Thanks, Chris
The batteries I'm looking at have a PCM/BMS built into each and the price includes a charger. I just measured my tail battery case and it will easily hold two BLF-1206T, 12V 6 AH units. Then I read the spec sheet and found that the manufacturer does not recommend parallel (or series) connections. I've sent them a message including the dimensions of my battery compartments and asking for suggestions. I know they have a 9 AH battery that will fit in my baggage compartment battery holder and a 6 AH battery that will fit in the tail, but I want more. I estimate my current power requirements at 1.8 amp hours so, for a 5 hour flight, I'd need 7.2 amp hours. I guess a 9 Ah battery with a 6 Ah backup in the tail would work for just about any flight I might want to do, but as I said... I want plenty of power. "Chris Nicholas" wrote in message ... Dan, not wishing to teach granny to suck eggs, but if you go for Lipo in the tail (or anywhere), make sure you have a proper battery management system in addition to a charger â?" apparently the significant number of fires in Lipos in model aircraft were due to inadequate or absent BMS. Otherss here will have more first-hand knowledge. (The Lak FES comes with a proper BMS for this very reason.) Chris N |
#53
|
|||
|
|||
glider battery duration problems
"Dan Marotta" wrote Then I read the spec sheet and found that the manufacturer does not recommend parallel (or series) connections. I've sent them a message including the dimensions of my battery compartments and asking for suggestions. If you talk to the other people (like RC) guys, discharge is not the problem, but it is in the charging. If you were to put two packs in parallel, provide a Y plug so that you can charge each isolated from the other. Jim in NC |
#54
|
|||
|
|||
glider battery duration problems
Morgans wrote, On 10/6/2013 8:15 PM:
"Dan Marotta" wrote Then I read the spec sheet and found that the manufacturer does not recommend parallel (or series) connections. I've sent them a message including the dimensions of my battery compartments and asking for suggestions. If you talk to the other people (like RC) guys, discharge is not the problem, but it is in the charging. If you were to put two packs in parallel, provide a Y plug so that you can charge each isolated from the other. It's OK to talk to the RC guys, but PLEASE follow the battery manufacturer's recommendations instead of the RC guys. The RC guys are using different chemistries, typically discharge rapidly (15-20 minutes), recharge rapidly, use special chargers, and do not use a BMS (battery management system). In addition, some of the things you know about SLA batteries can cause you trouble when applied to Lithium batteries. Don't guess - look at the instructions and data sheets, and talk to the manufacturer. Even the people selling them might not be knowledgeable enough, because this is new territory for us. -- Eric Greenwell - Washington State, USA (change ".netto" to ".us" to email me) |
#55
|
|||
|
|||
glider battery duration problems
Please correct me if I got this wrong:
1.LiFePO4 with BMS are less likely to self-ignite compared to other lithium based batteries (or LiFEPO4 without BMS). But LiFePO4 still contain lithium and will make an intense and difficult to extinguish fire should they inadvertently ignite. 2.If an undamaged LiFePO4 battery self-ignites, it is most likely to occur during charging due to a malfunctioning charger or BMS. The battery overheats to the point of ignition due to internal resistance to the current applied by the battery charger. 3.If a LiFePO4 battery is charged while it is in a battery box, it may reach a higher temperature due to a reduced ability to dissipate heat to the surrounding environment. If it is a hot day or if the glider is in the sun, the charging battery will reach a higher temperature. 4.BMS have a fail-safe method of monitoring battery temperature. The BMS will suspend or reduce charging current should the battery temperature exceed a safe level. 5.The BMS makes charging a LiFePO4 battery, without removing it from the battery box in the glider, a safe operation. Manufacturers anticipate this scenario. 6.If I have a 5 AMP master fuse at my LiFePO4 battery terminals and I have a partial short that draws 4.5 AMPs. The BMS will detect any dangerous temperature rise and disconnect the circuit. 7.If the BMS is damaged in an accident, mishandling, or by age-related component failure, all bets are off. A LiFePO4 battery with a damaged BMS will be obviously "dead". |
#56
|
|||
|
|||
glider battery duration problems
8.LiFePO4 batteries with BMS are compatible with solar panel chargers.
|
#57
|
|||
|
|||
glider battery duration problems
Thanks. When I finally make contact with the manufacturer, I'll bring that
up. In the meantime, I'm thinking of fishing another pair of wires from the tail to the cockpit. Since it appears that I can stick two of these 6 Ah batteries in my tail battery box (which then slides into a compartment in the tail), it should be simple to add another switch to the panel to control it. I think two of these batteries are about the same weight as the three SLAs in the box now and, due to their shorter length, would lower the mass deeper into the fin. "Morgans" wrote in message ... "Dan Marotta" wrote Then I read the spec sheet and found that the manufacturer does not recommend parallel (or series) connections. I've sent them a message including the dimensions of my battery compartments and asking for suggestions. If you talk to the other people (like RC) guys, discharge is not the problem, but it is in the charging. If you were to put two packs in parallel, provide a Y plug so that you can charge each isolated from the other. Jim in NC |
#58
|
|||
|
|||
glider battery duration problems
Eric, I have absolute faith in my ram air parachute. Having said that, I
don't relish the idea of bailing out of a flaming glider! Since I have no direct knowledge of these new-fangled batteries, I will listen only to the manufacturer when designing my system. When and if I get it done, I'll post the design. "Eric Greenwell" wrote in message ... Morgans wrote, On 10/6/2013 8:15 PM: "Dan Marotta" wrote Then I read the spec sheet and found that the manufacturer does not recommend parallel (or series) connections. I've sent them a message including the dimensions of my battery compartments and asking for suggestions. If you talk to the other people (like RC) guys, discharge is not the problem, but it is in the charging. If you were to put two packs in parallel, provide a Y plug so that you can charge each isolated from the other. It's OK to talk to the RC guys, but PLEASE follow the battery manufacturer's recommendations instead of the RC guys. The RC guys are using different chemistries, typically discharge rapidly (15-20 minutes), recharge rapidly, use special chargers, and do not use a BMS (battery management system). In addition, some of the things you know about SLA batteries can cause you trouble when applied to Lithium batteries. Don't guess - look at the instructions and data sheets, and talk to the manufacturer. Even the people selling them might not be knowledgeable enough, because this is new territory for us. -- Eric Greenwell - Washington State, USA (change ".netto" to ".us" to email me) |
#59
|
|||
|
|||
glider battery duration problems
On Saturday, Dan Marotta wrote:
This looks very interesting to me: http://www.bioennopower.com/collecti...ifepo4-battery Here is another one you might take a look at if considering Lithium power. I have one of these on my other flying machine and it works well. http://shoraipower.com/products |
#60
|
|||
|
|||
glider battery duration problems
On Monday, October 7, 2013 12:44:54 PM UTC-4, Soartech wrote:
On Saturday, Dan Marotta wrote: This looks very interesting to me: http://www.bioennopower.com/collecti...ifepo4-battery Here is another one you might take a look at if considering Lithium power. I have one of these on my other flying machine and it works well. http://shoraipower.com/products You should explain what Shorai means by (for example) "18 AH PbEQ" before you make such a recommendation. But I predict that once you understand this well enough to explain it, you'll withdraw the recommendation :-). These are starter batteries. Unsuited for gliders. T8 |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Any EASA problems with USA glider licence? | POPS | Soaring | 8 | September 7th 12 09:10 PM |
Glider Pilot Network Server Problems | Andy Kirkland | Soaring | 0 | February 20th 08 03:07 PM |
Silver Duration | [email protected] | Soaring | 5 | April 11th 07 02:12 PM |
Bigger Battery holders from glider manufacturers | Gary Emerson | Soaring | 5 | May 31st 06 07:53 AM |
aircraft financing duration help | news.det.sbcglobal.net | Aviation Marketplace | 1 | June 30th 04 06:27 PM |