![]() |
If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
![]()
https://en.wikipedia.org/wiki/Bede_BD-5
The Bede BD-5 Micro is a series of small, single-seat homebuilt aircraft created in the late 1960s by US aircraft designer Jim Bede and introduced to the market primarily in kit form by the now-defunct Bede Aircraft Corporation in the early 1970s. The BD-5 has a small, streamlined fuselage holding its semi-reclined pilot under a large canopy, with the engine installed in a compartment in the middle of the fuselage, and a propeller-driving engine - or jet engine in the BD-5J variant - mounted immediately to the rear of the cockpit. The combination of fighter-like looks and relatively low cost led to the BD-5 selling over 5,000 kits or plans, with approximately 12,000 orders being taken for a proposed factory-built, FAA-certified version. However, few of the kit versions were actually completed due to the company's bankruptcy in the mid-1970s, and none of the factory built "D" models were produced, as a result of the failure to find a reliable engine for the design. In total, only a few hundred BD-5 kits were completed, although many of these are still airworthy today. The BD-5J version holds the record for the world's lightest single-engine jet aircraft, weighing only 358.8 lb (162.7 kg). After more than 5,100 kits had been delivered to prospective builders, the kits stopped shipping as well. Although the company was effectively bankrupt at this point, work on the BD-5D continued for some time. The bankruptcy became official in 1979, by which point the BD-5 project was long dead. During the bankruptcy proceedings, it was learned that the money ostensibly being used to build kits was instead being spent on a variety of other projects. As a result, Bede entered a consent decree with the FTC to no longer accept deposits on aircraft for a period of 10 years. Many owners stored, abandoned, or sold their incomplete kits, but a few hundred diehard builders finished them with a variety of engines, with installations designed by third parties and former Bede Aircraft dealers. Having to hunt for an engine was only one problem. The time to build the aircraft was much longer than quoted, as much as 3,500 hours. Some of this was due to the need to fit their selected engine into an airframe designed for the Hirth, which was no longer available. Additionally, the construction techniques had improved somewhat since early Bede designs, but fastening the panels still required drilling, deburring, dimpling, drilling again and deburring again for each rivet. With the original mixed-construction design this would not have been as much of a task, but with the all-metal version this was extremely time consuming. While Bede claimed the aircraft could be put together by anyone in a garage, builders generally agree that doing so without proper construction techniques could result in a potentially dangerous aircraft. One way to overcome that issue is to use a set of properly laid-out jigs to align and drill the pilot holes for the airframe, wings and other components. For all of these reasons, it was some time before completed BD-5s started to appear. Role Homebuilt Manufacturer Bede Aviation Designer Jim Bede First flight September 12, 1971 Introduction 1970s Status ~150 airworthy, ~30 flying While the new Hirth engine was being tested, Bede decided to create a variant of the BD-5 with a small jet engine. The result was the sleek BD-5J (also known as the "Acrostar Jet "), a 300 mph (260 kn; 480 km/h) aircraft. The design used the Sermel TRS-18-046 turbojet which produced 225 lbf (1.00 kN) thrust and was used on a Caproni certified motorglider design. The original engines were produced under license by Ames Industrial in the USA. The wing was modified to an "intermediate" size between the original A and B wings, with a 17 ft (5.2 m) span. Bob Bishop purchased 20 BD-5J kits as soon as they had appeared, and many of the flying examples started life in this batch of 20. Versions from the original batch became a popular airshow fixture. Throughout the 1980s and until 1991, Coors flew two of them as the "Silver Bullets". Budweiser also had a BD-5J called the Bud Light Jet, but that contract has long expired and the aircraft was lost as a result of an engine compartment fire from which Bishop successfully bailed out. The aircraft also appeared in the opening sequence of the James Bond film Octopussy. Specifications Bede BD-5B, 70 hp General characteristics Crew: One Length: 13 ft 7 in (4.13 m) Wingspan: 21 ft 6 in (6.55 m) Height: 4 ft 2 in (1.28 m) Wing area: 47.4 sq ft (4.40 m2) Aspect ratio: 9.8 Empty weight: 355 lb (161 kg) Max takeoff weight: 659 lb (299 kg) Powerplant: 1 × Hirth two-cylinder two-stroke, 70 hp (52 kW) Propellers: 2-bladed, 3 ft 8 in (1.12 m) diameter fixed pitch, wooden Performance Maximum speed: 232 mph; 201 kn (373 km/h) at sea level Cruise speed: 229 mph; 199 kn (369 km/h) at 2,285 m (7,497 ft) Stall speed: 55 mph; 48 kn (89 km/h) flaps down Range: 935 mi; 812 nmi (1,504 km) optimum, with 30 min reserve Rate of climb: 1,919 ft/min (9.75 m/s) at sea level Take-off distance to 50 ft (15 m): 226 m (741 ft) Landing distance from 50 ft (15 m): 253 m (830 ft) FLS Microjet Data from FLS Microjet General characteristics Crew: 1 Length: 13 ft (4.0 m) Wingspan: 17 ft (5.2 m) Height: 5 ft 9 in (1.75 m) Empty weight: 416 lb (189 kg) Gross weight: 860 lb (390 kg) Fuel capacity: 30 U.S. gallons (110 L; 25 imp gal) Powerplant: 1 × PBS TJ-100 turbojet Performance Maximum speed: 278 kn; 515 km/h (320 mph) Stall speed: 58 kn; 108 km/h (67 mph) Range: 200 nmi (230 mi; 370 km) g limits: +6 * |
Thread Tools | |
Display Modes | |
|
|
![]() |
||||
Thread | Thread Starter | Forum | Replies | Last Post |
Pushers, p1 - Bede XBD-2.jpg (1/1) | Mitchell Holman[_9_] | Aviation Photos | 0 | March 1st 18 02:14 PM |
Pima museum Batch 3 [12/43] - Bede BD-5J Micro-jet DSC_3041.jpg (1/1) | Indrek | Aviation Photos | 0 | December 24th 10 11:46 PM |
US 20100815 _02_ Alaska Aviation Heritage Museum Anchorage Bede BD-5 | Graham Harrison[_2_] | Aviation Photos | 0 | November 1st 10 09:57 AM |
He's Baaaaack! Bede | Dan Nafe | Home Built | 12 | July 14th 07 08:42 PM |